bleeding fuel lines - TheDieselGarage.com
Thread Details Posted by jdreda, this thread has received 15 replies and been viewed 1986 times.

Reply
 
LinkBack Thread Tools Display Modes
post #1 of 16 (permalink) Old 04-05-2009, 01:44 PM Thread Starter
Junior Member
 
jdreda's Avatar
 
Join Date: Dec 2007
Location: huntsburg, ohio
Posts: 33
Points: 1,346
Thanks: 1
Thanked 0 Times in 0 Posts
bleeding fuel lines

I just replaced my injection pump in my 03 lb7 and was wondering if there was any special way to bleed the lines or do i just keep pushing the primer pump while someone cranks the engine over.
jdreda is offline  
Sponsored Links
Advertisement
 
post #2 of 16 (permalink) Old 04-06-2009, 01:32 AM
Mafia member #105
 
ripmf666's Avatar
 
Join Date: Dec 2008
Location: Kansas City Mo
Posts: 2,262
Points: 65,090
Thanks: 135
Thanked 153 Times in 131 Posts
Send a message via AIM to ripmf666 Send a message via Yahoo to ripmf666
Keep priming and cranking over let up and keep trying. Most of the time they will fire up.

Devil Girl 2006 2500HD LBZ Ex-Cab 4x4

EFI Live tuned by IdahoRob,MPI twins installed by BigDipper,PPE lift pump, BigDipper 30% injectors, BigDipper Trans Precion ML converter.PPE Twin Cp3's.

Alot Of thanks To Kat & Pat at duramax diesels, Joe & Dan at PPE,George aka BigDipper
RIP LBZ 6/1/08@5:44pm she was strong

She's Alive again

Born on July 27, 2008, 11:59:02 PM

http://www.dieselbuilder.com/Media/P...adoBuild_2.pdf
ripmf666 is offline  
post #3 of 16 (permalink) Old 04-06-2009, 10:47 PM
Diesel Mafia #67
 
blackcloudCTD95's Avatar
 
Join Date: Jun 2006
Location: jensen beach fl
Posts: 11,283
Points: 53,194
Thanks: 257
Thanked 202 Times in 153 Posts
NEVER crack open a CR injector line..... Fill the filter with fuel... crack the little plastic screw, prime until you see fuel squirt out.. close it walk back in crank it.. and repeat until you get it running....

Jordan

95-dodge 2500 built to the hill... - sold to litle brother
03- stroker 6.0 studs and basic BS

blackcloudCTD95 is offline  
post #4 of 16 (permalink) Old 04-06-2009, 11:12 PM
TDG Official Poo Flinger
 
TANK'S 250's Avatar
 
Join Date: Jan 2005
Location: Chesapeake, VA
Posts: 5,268
Points: 23,709
Thanks: 77
Thanked 474 Times in 262 Posts
Images: 38
I don't know if its different for your truck...

But I don't think cranking it is a good idea...


When I did my entire Stage II fuel system....I just cycled the key about 10 times,...then it fired right up...

____________________________

2005 F-250, CC,SB,PSD, MANUAL TRANNY

Icon 4.5" lift, 41" IROKS, and some other stuff

Special thanks to:


TrustedPerformance.com
KLMperformance.com
Black Ops Bumpers
FarmboyFabrications.com


TIRES AND WHEELS- 41" IROK Super Swampers, 20 x 10 AR Mojave Teflon-STEERING UPGRADE- Donahoe Racing Dual Stabilizers -FRONT SUSPENSION- Donahoe Racing 4.5" lift -REAR SUSPENSION- 6" Procomp Springs, Farmboy Fabrications Custom Traction Bars-FRONT AXLE UPGRADES- ARB Air locker/ 4.56 Precision Gears -REAR AXLE UPGRADES- ARB Air Locker/ 4.56 Precision Gears -ENGINE UPGRADES -SCT XCAL II w/ Extreme track file- ARP Headstuds - TRUSTED PERFORMANCE Stage II fuel and Oil system - ACCUFAB Intake Elbow - AFE Stage II Intake - MBRP Turbo back Stainless Steel Exhaust - MERLIN controls SPEED WIZARD-TRANSMISSION UPGRADES- Southbend 550+ HP Clutch -INTERIOR MODS-Gauge Works Quad A-pillar pod - Autometer Cobalt Series Gauges Pyro, Boost, Tranny - Cobra Inverter Remote Switch - Cobra Limited Edition Harley Davidson CB - Python Custom alarm system, wired into train horns - Hi-Lift Extreme jack w/ off road base -10,000 watt inverter - 15 gallons of air - Porter Cable 115 volt, 2.5hp Air Compressor - Rhino....Bed liner - EXTERIOR MODS- Harley Heads & Smoked tails- Crown SS braided Brake Lines -Custom Fabricated Front Bumper/ Brushguard w/ Custom Herculiner - (2) 8" Procomp Spotlights -(2) 5" Procomp Spotlights - (2) 5"Procomp Fluted lights - (2) 12 ton Recovery Shackles - Custom Fabricated Safari Rack w/ Custom Herculiner - (8 ) 3" x 5" Procomp Fluted lights - Grover...Triple Train Horns - Wilson 4' Fiberglass CB antenna - Stealth Bulbs Chrome signal bulbs - Dominator...Cowl Hood - Custom Herculined Rocker panels - AMP Research Powersteps - Bushwacker Cut-out Fender Flares - Ventshades - LEER Bed cap - Recon Line of Fire, rear light bar,...and a couple other things
TANK'S 250 is offline  
post #5 of 16 (permalink) Old 04-06-2009, 11:32 PM
Mafia member #105
 
ripmf666's Avatar
 
Join Date: Dec 2008
Location: Kansas City Mo
Posts: 2,262
Points: 65,090
Thanks: 135
Thanked 153 Times in 131 Posts
Send a message via AIM to ripmf666 Send a message via Yahoo to ripmf666
Quote:
Originally Posted by TANK'S 250 View Post
I don't know if its different for your truck...

But I don't think cranking it is a good idea...


When I did my entire Stage II fuel system....I just cycled the key about 10 times,...then it fired right up...

Tank does Fords come with a factory lift pump? The Cp3 pump has a high pressureside and a pump that pulls with vacuum from the tank to the Cp3.We can only primer ontop of the filter then crank and then try again,makes it nice having a extra hand or a lift pump installed.

Devil Girl 2006 2500HD LBZ Ex-Cab 4x4

EFI Live tuned by IdahoRob,MPI twins installed by BigDipper,PPE lift pump, BigDipper 30% injectors, BigDipper Trans Precion ML converter.PPE Twin Cp3's.

Alot Of thanks To Kat & Pat at duramax diesels, Joe & Dan at PPE,George aka BigDipper
RIP LBZ 6/1/08@5:44pm she was strong

She's Alive again

Born on July 27, 2008, 11:59:02 PM

http://www.dieselbuilder.com/Media/P...adoBuild_2.pdf
ripmf666 is offline  
post #6 of 16 (permalink) Old 04-07-2009, 12:07 AM
TDG Official Poo Flinger
 
TANK'S 250's Avatar
 
Join Date: Jan 2005
Location: Chesapeake, VA
Posts: 5,268
Points: 23,709
Thanks: 77
Thanked 474 Times in 262 Posts
Images: 38
nope...no lift pump.....that is why I said that I didn't know if it would be the same.'


I tried.

____________________________

2005 F-250, CC,SB,PSD, MANUAL TRANNY

Icon 4.5" lift, 41" IROKS, and some other stuff

Special thanks to:


TrustedPerformance.com
KLMperformance.com
Black Ops Bumpers
FarmboyFabrications.com


TIRES AND WHEELS- 41" IROK Super Swampers, 20 x 10 AR Mojave Teflon-STEERING UPGRADE- Donahoe Racing Dual Stabilizers -FRONT SUSPENSION- Donahoe Racing 4.5" lift -REAR SUSPENSION- 6" Procomp Springs, Farmboy Fabrications Custom Traction Bars-FRONT AXLE UPGRADES- ARB Air locker/ 4.56 Precision Gears -REAR AXLE UPGRADES- ARB Air Locker/ 4.56 Precision Gears -ENGINE UPGRADES -SCT XCAL II w/ Extreme track file- ARP Headstuds - TRUSTED PERFORMANCE Stage II fuel and Oil system - ACCUFAB Intake Elbow - AFE Stage II Intake - MBRP Turbo back Stainless Steel Exhaust - MERLIN controls SPEED WIZARD-TRANSMISSION UPGRADES- Southbend 550+ HP Clutch -INTERIOR MODS-Gauge Works Quad A-pillar pod - Autometer Cobalt Series Gauges Pyro, Boost, Tranny - Cobra Inverter Remote Switch - Cobra Limited Edition Harley Davidson CB - Python Custom alarm system, wired into train horns - Hi-Lift Extreme jack w/ off road base -10,000 watt inverter - 15 gallons of air - Porter Cable 115 volt, 2.5hp Air Compressor - Rhino....Bed liner - EXTERIOR MODS- Harley Heads & Smoked tails- Crown SS braided Brake Lines -Custom Fabricated Front Bumper/ Brushguard w/ Custom Herculiner - (2) 8" Procomp Spotlights -(2) 5" Procomp Spotlights - (2) 5"Procomp Fluted lights - (2) 12 ton Recovery Shackles - Custom Fabricated Safari Rack w/ Custom Herculiner - (8 ) 3" x 5" Procomp Fluted lights - Grover...Triple Train Horns - Wilson 4' Fiberglass CB antenna - Stealth Bulbs Chrome signal bulbs - Dominator...Cowl Hood - Custom Herculined Rocker panels - AMP Research Powersteps - Bushwacker Cut-out Fender Flares - Ventshades - LEER Bed cap - Recon Line of Fire, rear light bar,...and a couple other things
TANK'S 250 is offline  
post #7 of 16 (permalink) Old 04-07-2009, 12:25 AM
Mafia member #105
 
ripmf666's Avatar
 
Join Date: Dec 2008
Location: Kansas City Mo
Posts: 2,262
Points: 65,090
Thanks: 135
Thanked 153 Times in 131 Posts
Send a message via AIM to ripmf666 Send a message via Yahoo to ripmf666
Quote:
Originally Posted by TANK'S 250 View Post
nope...no lift pump.....that is why I said that I didn't know if it would be the same.'


I tried.

When you said (I just cycled the key about 10 times,...then it fired right up...) Did you crank it over at all or just on and off with the key.I thought some of the fords came with a factory lift pump.

Devil Girl 2006 2500HD LBZ Ex-Cab 4x4

EFI Live tuned by IdahoRob,MPI twins installed by BigDipper,PPE lift pump, BigDipper 30% injectors, BigDipper Trans Precion ML converter.PPE Twin Cp3's.

Alot Of thanks To Kat & Pat at duramax diesels, Joe & Dan at PPE,George aka BigDipper
RIP LBZ 6/1/08@5:44pm she was strong

She's Alive again

Born on July 27, 2008, 11:59:02 PM

http://www.dieselbuilder.com/Media/P...adoBuild_2.pdf
ripmf666 is offline  
post #8 of 16 (permalink) Old 04-07-2009, 01:14 AM
TDG Official Poo Flinger
 
TANK'S 250's Avatar
 
Join Date: Jan 2005
Location: Chesapeake, VA
Posts: 5,268
Points: 23,709
Thanks: 77
Thanked 474 Times in 262 Posts
Images: 38
on and off....no cranking....I let the fuel pump do all the work

____________________________

2005 F-250, CC,SB,PSD, MANUAL TRANNY

Icon 4.5" lift, 41" IROKS, and some other stuff

Special thanks to:


TrustedPerformance.com
KLMperformance.com
Black Ops Bumpers
FarmboyFabrications.com


TIRES AND WHEELS- 41" IROK Super Swampers, 20 x 10 AR Mojave Teflon-STEERING UPGRADE- Donahoe Racing Dual Stabilizers -FRONT SUSPENSION- Donahoe Racing 4.5" lift -REAR SUSPENSION- 6" Procomp Springs, Farmboy Fabrications Custom Traction Bars-FRONT AXLE UPGRADES- ARB Air locker/ 4.56 Precision Gears -REAR AXLE UPGRADES- ARB Air Locker/ 4.56 Precision Gears -ENGINE UPGRADES -SCT XCAL II w/ Extreme track file- ARP Headstuds - TRUSTED PERFORMANCE Stage II fuel and Oil system - ACCUFAB Intake Elbow - AFE Stage II Intake - MBRP Turbo back Stainless Steel Exhaust - MERLIN controls SPEED WIZARD-TRANSMISSION UPGRADES- Southbend 550+ HP Clutch -INTERIOR MODS-Gauge Works Quad A-pillar pod - Autometer Cobalt Series Gauges Pyro, Boost, Tranny - Cobra Inverter Remote Switch - Cobra Limited Edition Harley Davidson CB - Python Custom alarm system, wired into train horns - Hi-Lift Extreme jack w/ off road base -10,000 watt inverter - 15 gallons of air - Porter Cable 115 volt, 2.5hp Air Compressor - Rhino....Bed liner - EXTERIOR MODS- Harley Heads & Smoked tails- Crown SS braided Brake Lines -Custom Fabricated Front Bumper/ Brushguard w/ Custom Herculiner - (2) 8" Procomp Spotlights -(2) 5" Procomp Spotlights - (2) 5"Procomp Fluted lights - (2) 12 ton Recovery Shackles - Custom Fabricated Safari Rack w/ Custom Herculiner - (8 ) 3" x 5" Procomp Fluted lights - Grover...Triple Train Horns - Wilson 4' Fiberglass CB antenna - Stealth Bulbs Chrome signal bulbs - Dominator...Cowl Hood - Custom Herculined Rocker panels - AMP Research Powersteps - Bushwacker Cut-out Fender Flares - Ventshades - LEER Bed cap - Recon Line of Fire, rear light bar,...and a couple other things
TANK'S 250 is offline  
post #9 of 16 (permalink) Old 04-07-2009, 01:25 AM
off to another home
 
SSpeeDEMONSS's Avatar
 
Join Date: Feb 2006
Posts: 15,472
Points: 54,217
Thanks: 585
Thanked 1,364 Times in 1,111 Posts
Garage
Send a message via Yahoo to SSpeeDEMONSS
Quote:
Originally Posted by ripmf666 View Post
When you said (I just cycled the key about 10 times,...then it fired right up...) Did you crank it over at all or just on and off with the key.I thought some of the fords came with a factory lift pump.
its not a lift pump. its the stock fuel pump. HFCM to be exact. if you cycle the key on the pump goes on for a few seconds or until pressure is built. if you continue to cycle it it will eventually bleed air out of the lines.

Garrett



BRING BACK THE OLD TDG!
oh well, i have a map to the darkside

SSpeeDEMONSS is offline  
post #10 of 16 (permalink) Old 04-07-2009, 01:43 AM
Mafia member #105
 
ripmf666's Avatar
 
Join Date: Dec 2008
Location: Kansas City Mo
Posts: 2,262
Points: 65,090
Thanks: 135
Thanked 153 Times in 131 Posts
Send a message via AIM to ripmf666 Send a message via Yahoo to ripmf666
So its closer to a lift pump then what the Dmax comes with lol, If we just turn the key on and off we get nothing lol.

Devil Girl 2006 2500HD LBZ Ex-Cab 4x4

EFI Live tuned by IdahoRob,MPI twins installed by BigDipper,PPE lift pump, BigDipper 30% injectors, BigDipper Trans Precion ML converter.PPE Twin Cp3's.

Alot Of thanks To Kat & Pat at duramax diesels, Joe & Dan at PPE,George aka BigDipper
RIP LBZ 6/1/08@5:44pm she was strong

She's Alive again

Born on July 27, 2008, 11:59:02 PM

http://www.dieselbuilder.com/Media/P...adoBuild_2.pdf
ripmf666 is offline  
Sponsored Links
Advertisement
 
Reply

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the TheDieselGarage.com forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in









Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
I have foresale a Dj fuel intisier kit with braided lines. All lines and fittings tha Robts Whats Been Sold 3 05-01-2008 11:10 PM
Fuel Lines hemichallenger 24 Valve Performance 1 02-05-2008 04:12 PM
Fuel lines Big Gray dodge 5.9L Cummins 12 Valve (1994-1998.5) 5 01-12-2008 03:38 PM
Fuel Lines JMS8800 2003-2007 6.0L Power Stroke 10 06-06-2007 02:27 PM
Fuel Lines rshort Whats Been Sold 1 04-03-2006 03:37 PM

Posting Rules  
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome